SUN REFINING AND MARKETING COMPANY -- TOLUENE  -- 6810-00-579-8431
<pre>=====================  Product Identification  =====================

Product ID:TOLUENE
MSDS Date:04/05/1989
FSC:6810
NIIN:00-579-8431
=== Responsible Party ===
Company Name:SUN REFINING AND MARKETING COMPANY
Address:TEN PENN CENTER 1801 MARKET STREET
City:PHILADELPHIA
State:PA
ZIP:19103-1699
Country:US
Info Phone Num:215-293-9270 (1631-0759)
Emergency Phone Num:215-977-6172 (0800-1630)
Preparer's Name:RAMONA PANSON
CAGE:3T335
=== Contractor Identification ===
Company Name:SUN COMPANY  INC
Address:1801 MARKET STREET
Box:City:PHILADELPHIA
State:PA
ZIP:19103-1699
Country:US
Phone:800-964-8861
CAGE:78628
Company Name:SUN REFINING AND MARKETING CO
Address:676 E SWEDESFORD RD
City:WAYNE
State:PA
ZIP:19087-1612
Country:US
CAGE:3T335

=============  Composition/Information on Ingredients  =============

Ingred Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 99%+%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:BENZENE  (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <1%
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:LD50 (ORAL RAT) IS 5 GM/KG
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST- PULMONARY ASPIRATION
    HAZARD IF SWALLOWED AND VOMITING OCCURS. EYE- CONTACT MAY CAUSE
    MODERATE TO SEVERE IRRITATION. INHALE- IRRITATION TO EYES, NOSE,
    CNS. CHRONIC: INHALE- REPEATED EXCE SSIVE EXPOSURES MAY CAUSE
    CHRONIC, ADVERSE SYSTEMIC EFFECTS. SKIN- MODERATE IRRITATION AND
    DEFATTING.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
    LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:DIZZINESS, LOSS OF BLANCE AND COORDITATION,
    UNCONSCIOUSNESS, COMA, RESPIRATORY FAILURE AND DEATH.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
    OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
    RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.

=======================  First Aid Measures  =======================

First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
    GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
    FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
    SKIN:REMOVE  CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
    IRRITATION PERSISTS, GET MEDICAL ADVICE.  INGESTION:DO NOT INDUCE
    VOMITING. GIVE NOTHING BY MOUTH. GET IMMEDIATE MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:48.0F,8.9C
Autoignition Temp:Autoignition Temp Text:997F
Lower Limits:1.2
Upper Limits:7.1
Extinguishing Media:USE CARBON DIOXIDE, CHEMICAL FOAM, WATER FOG,
    SAND/DIRT.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
    FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
    SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID (FLASH POINT LESS THAN
    100F).

==================  Accidental Release Measures  ==================

Spill Release Procedures:PROEVENT IGNITION, STOP LEAK, VENTILATE AREA.
    CONTAIN SPILL. USE WATER SPRAY TO DISPERSE VAPORS. KEEP UPWIND OF
    LEAK. WEAR SCBA FOR LARGE SPILL. ADVISE EPA; STATE AGENCY IF
    REQUIRED. ABSORB ON INERT M ATERIAL.
Neutralizing Agent:NOT APPLICABLE.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
    AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
    CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
    PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
    USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. FOR
    INDUSTRIAL USE  ONLY.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
    EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED ORGANIC VAPOR
    CARTRIDGE AND DUST/MIST PRE-FILTER RESPIRATORS AS PER CURRENT 29
    CFR 1910.134, INSTRUCTIONS/ WARNINGS AND NIOSH-RESPIRATOR
    SELECTION.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
    LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTED.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY GOGGLES WITH OPTIONAL FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. WEAR
    IMPERVIOUS PROTECTIVE GEAR.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
    RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
    FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
    NOT BREATHE VAPORS OR MISTS.

==================  Physical/Chemical Properties  ==================

HCC:F2
Boiling Pt:=110.6C, 231.F
Melt/Freeze Pt:=-95.C, -139.F
Vapor Pres:26
Vapor Density:3.2
Spec Gravity:0.87
Evaporation Rate &amp; Reference:(ETHYL ETHER=1) 5X SLOWER
Solubility in Water:0.047 % BY VOL.
Appearance and Odor:COLORLESS LIQUID WITH PLEASANT SWEET ODOR.
Percent Volatiles by Volume:100

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE AND ASPHYXIANTS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
    APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DO NOT
    FLUSH TO DRAIN/STORM SEWER. INCINERATE UNDER CONTROLLED CONDITIONS.
    DRAIN TO CHEMICAL WA STE PLANT.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.